Warrick Power Plant

Warrick Generating Station is a coal-fired electricity-generating station, located southeast of Newburgh in Warrick County in Indiana, US.

Warrick Generating Station
Country	United States
Location	Anderson Township, Warrick County, near Newburgh, Indiana
Coordinates	37°54′53″N 87°20′01″W
Status	Operational
Commission date	Unit 1: April, 1960 Unit 2: January 1964 Unit 3: October 1965 Unit 4: October 1970
Owners	AGC Division of APG Inc., Alcoa
Thermal power station
Primary fuel	Bituminous coal
Cooling source	Ohio River
Power generation
Nameplate capacity	755 MW

It sits on the north bank of Ohio River, downstream of the F. B. Culley Generating Station. The plant has four coal-fired, steam-powered turbines with a combined generating capacity of 791 MWe. Alcoa owns three of the four generating stations, which were placed into service in the early 1960s. The largest unit, known as Unit 4, is 323-MWe unit jointly owned by Alcoa and Vectren. This larger unit was placed in operation in 1970.^[1]

Fuel

The Power Plant is primarily fueled by Illinois Basin coal, which is mined from the nearby region. It receives approximately 2 million tons of coal annually through both rail and truck shipments.

Environmental impact

Warrick Plant discharges all of its waste heat (about twice its electrical output) into Ohio River. In 2006, Warrick Plant was the third most-polluting major power station in the US in terms of sulphur dioxide gas emission rate: it discharged 32.69 pounds (14.83 kg) of SO₂ for each MWh of electric power produced that year (92,919 tons of SO₂ per year in total).^[2]

In light of the high emissions and increasing regulation, Alcoa commenced a large scale $400 million environmental investment to improve emission levels. In December 2008, the project was complete and included wet-flue gas desulphurization equipment (also known as scrubbers). This control equipment significantly reduced sulfur dioxide emissions beyond those required by regulation. Vectren also contributed to the upgrades on its share of Unit 4.

The environmental control system also included gypsum dewatering and handling facilities, dry-ash handling, new coal handling equipment and improved control facilities. With the control systems fully operational and online in 2009, the plant saw more than a 95 percent reduction in sulfur dioxide emissions and other compounds.

See also

• Indiana portal
• Energy portal

• List of power stations in Indiana
• Global warming